Seasoned Advice is a question and answer site for professional and amateur chefs. Join them; it only takes a minute:

Sign up
Here's how it works:
  1. Anybody can ask a question
  2. Anybody can answer
  3. The best answers are voted up and rise to the top

I enjoy using my cast-iron skillet, but how can I minimize the amount of food that sticks to it while cooking? I apply oil after cleaning, and for the most part, I only clean it with hot water and a rag.

For the most part, breads (pancakes, sandwiches) and meats do fine, but I have particular trouble with potatoes and fried eggs.

What causes sticking and what can I do to minimize the it?

share|improve this question
up vote 12 down vote accepted

The first rule to keeping food from sticking to cast-iron is to keep it well primed - it sounds like you're doing that already. Beyond that, read these tips for cooking with stainless steel - they'll also apply to cast iron.

To summarize:

  • Food sticks when chemical bonds form between the food molecules and the metal.
  • Very hot oil helps to reduce sticking by instantly and continuously heating the food until it's surrounded by a layer of steam from its natural moisture content boiling. Let the oil get nice and hot before adding food.
  • Very hot oil also binds with the pan, so food can't. This is the principle behind priming the pan in the first place.

I have some theories regarding particular problem foods:

  • Most of the molecular bonding occurs from proteins. Egg whites are mostly protein.
  • Frying potatoes creates surfactants in the oil, which cause oil and water to mix. This reduces the effect of the protective layer of steam. (Some people save and re-use cooking oil -- though it can impart a delicious flavor to later meals, it will also build up surfactants if the same oil is used too many times.)
  • Also, keep in mind that acidic foods like tomatoes will break down the protective patina and may make foods stick more readily.
share|improve this answer
thanks for this info - making sure that the heat was high enough helped wonders. – Abe Dec 28 '10 at 0:56
The patina is ultimately graphite. I don't think organic acids, which are weak, can attack it. – Neil G Nov 16 '15 at 21:20

Seasonning the pan properly helps a lot. Thin coat of oil. Bake at 550 for 20 minutes. Cool down. Repeat 3 to 5 times.

Then when using it, make sure you give it plenty of pre-heat time before putting the ingredients in it.

share|improve this answer

Placing the pan in a hot oven until the carbon starts to burn up is a good start. In professional kitchens chefs never let the pan touch soap and do not wash it in water. They will pure a few cups of coarse kosher salt in the pan, heat it on a hot stove for several minutes until it starts to smoke and then use a towel to move the salt around the pan to scrub the pan as the salt is very abrasive. After the salt is emptied a small amount of oil is spread around the pan evenly. The pan is then put on the burner until the oil burns off. When this happens the pan is usually very non-stick. Some chefs will go through the oiling of pan a couple times to build layers of the oil.

Soap is the worst since it will leave a residue that negatively flavors the food.

share|improve this answer
Soap will also take off layers of the carbon that is your season. Only ever wash your cast iron with soap if your intention is to reseason it. – Bryson Jun 27 '11 at 20:47

I also have problems with eggs especially sticking to my cast iron. I have found that making sure there is enough hot oil in the pan before putting the eggs in helps, as does cooking the eggs at a lower heat.

share|improve this answer

If you are going to cook something "sticky" like eggs or potato, you need to double-oil the pan. While the pan is cold, spray it with cooking spray. Then, after you heat it up, put another coat of oil in the pan. The cold-oil and the hot-oil should make separate layers that will keep your food from sticking.

share|improve this answer

I have had this issue to going to recondition as it never did this before. The best method I find it to oil it warm it let it cool completely then turn it back on and cook the eggs. I just cant stand this method as it takes a lot longer to get breakfast on the table.

share|improve this answer

Your Answer


By posting your answer, you agree to the privacy policy and terms of service.

Not the answer you're looking for? Browse other questions tagged or ask your own question.